 |
|
Flow Diagram
HS 1, 2, 3, 4 and 5
Condensate Mananagement
Water and oil condensate exists wherever
compressed air is used. Depending upon compressor capacities,
working and installation conditions, the volume of condensate
which exists in a compressed air system can range in between 3 and
2,640 gallons per month. For example, an installation, which
delivers 180 scfm of compressed air at 100 psi and is working 8
hours a day under atmospheric conditions of 700F, and 70% relative
humidity, generates 8 gallons of condensate per day.
Legislation requires that oil condensate
be separated from water condensate and disposed of properly. After
the
oil is separated, the water condensate can then be sent to the
sewer system. Legal requirements vary from place to place as to
the minimum acceptable oil content. The HS Series, when sized and
installed correctly, meets most legal requirements by providing a
residual oil content level in the condensate of 10 ppm.
|
Economic,
Automatic and Convenient
The
HS Series automatically separates
the oil from the water. All you have to do is fill the unit with
clean water, pre- soak the water filters, connect your condensate
discharge lines to any of the four 1/2' inch connections, and walk
away. The capital investment required represents a small fraction
of the cost which contracting a licensed condensate disposal
contractor would represent. An easy-to-use Test-set is provided to
check water purity and to know when to change the filtration
elements. A convenient oil-collection vessel with over-f low
safeguard collects the oil for safe disposal.
|
Home |
Next Page |
